+ Post New Thread
Page 1 of 21 1 2 3 4 5 11 ... LastLast
Threads 1 to 20 of 416

Forum: 450 fortwo - Technical Queries

Got a technical query? View this Forum first to check on Technical Queries past and present. ALSO see our DIY smartsheets available via our home page.

  1. Paint code

    Does anyone know the correct paint code for alloy wheels on the 450? Thanks.

    Started by Chopper, Yesterday 10:37
    • Replies: 1
    • Views: 40
    Yesterday 11:06 Go to last post
  2. Crashy smart

    Are they just that crashy? Ours seem to just crash I to every speed bump and pot hole! Or are the dampers/springs on ours goosed? Ta!

    Started by Karlos28, 8th June 2019 19:53
    • Replies: 4
    • Views: 450
    11th June 2019 10:55 Go to last post
  3. Replacement pipes

    Hello all, I am pretty new to smart cars and need some help please Can anyone point me in the right direction to order two new pipes, I dont know what they are called but both are damaged 1 is the smaller one 2 is a bigger pipe (on my car the previous owner looks like they cut it too short)...

    Started by smartdizzy, 4th June 2019 13:26
    • Replies: 5
    • Views: 353
    6th June 2019 16:41 Go to last post
  4. Assisted steering becomes stiff once in motion

    The power steering becomes really stiff once in motion but is great when, parking and rolling from start. Is this a simple case of the motor? Brabus 2004-5 74bhp

    Started by Pocetsize, 12th April 2019 23:22
    2 Pages
    1 2
    assisted steering stiff
    • Replies: 13
    • Views: 901
    6th June 2019 12:03 Go to last post
  5. Gear Indicator showing 0

    Hi 450 City Pure 61. All was going so well, then yesterday when i went to shift into a gear the display says 0 and there is no drive. Same when I try and get reverse. Engine starts and sounds good. Checked the actuator and that is moving in and out. Cleaned all plug connections I can see....

    Started by Squat, 13th May 2019 13:28
    2 Pages
    1 2
    • Replies: 16
    • Views: 733
    24th May 2019 08:20 Go to last post
  6. Strong starter turns the engine but sometimes will not fire

    The starter whirls the engine around but it's not firing. Has a 4-5 sec. cycle once the key is in Pos. 2 then try again turn the, key. Usually this occurs and by the third of fourth attempt the engine will start. I've removed the valve and fuel is in the system. The plugs and ignition cables...

    Started by Pocetsize, 18th May 2019 20:54
    • Replies: 2
    • Views: 378
    21st May 2019 18:00 Go to last post
  7. Water ingress in footwells around centre console

    Afternoon all Apologies in advance for the long read, but as you'll see, I'm confused . . . . . . so I've found water under the front carpets of the Smart - which from what I've read isn't all that unusual - but what is unusual is how it's dispersed. The majority of the water is around the...

    Started by the-chauffeur, 24th January 2019 21:18
    2 Pages
    1 2
    footwell, ingress, leak, water
    • Replies: 15
    • Views: 1,677
    21st May 2019 16:43 Go to last post
  8. Connector under warning triangle - main feed

    2005, 450 0.7l petrol the main connector to the warning triangle circuit is breaking apart. Glued it together about a month ago. But today various function stoped working again (clock power, repeater / activation lights on buttons etc. Is it possible to buy a replacement connector ? If so...

    Started by Robinb, 11th May 2019 10:35
    • Replies: 4
    • Views: 435
    11th May 2019 18:34 Go to last post
  9. Cam chain tension/replacement

    I have got a rattle noise that starts @3000 rpm.It happens as I change gear but is not gearbox related. Today I have been looking through the oil filler hole and found that by turning the engine over via the pulley @ every time the exhaust valve closes (seen through the plug hole) the cam sprocket...

    Started by peanut, 8th September 2018 17:08
    16 Pages
    1 2 3 ... 16
    • Replies: 151
    • Views: 7,722
    9th May 2019 12:23 Go to last post
  10. What the heck is this wire for?

    Found this loose under the passenger side. Canít be that important as Iím experiencing no issues with the car. Any ideas what this connection is for? Cheers.

    Started by 7hil, 28th April 2019 12:50
    2 Pages
    1 2
    • Replies: 15
    • Views: 916
    7th May 2019 08:47 Go to last post
  11. Bluetooth Accessory Installation Wiring Help

    I purchased a Bluetooth Module that just plugs into the AUX section pins at the back of my Grundig CD Radio. The Blue block socket just goes where my old iPod Holder AUX connection used to go. Seems easy enough but there is a Red 12V wire and a Black Ground Wire coming out of the Bluetooth...

    Started by 7hil, 30th April 2019 06:12
    • Replies: 4
    • Views: 522
    30th April 2019 23:10 Go to last post
  12. How to fit a sun blind to a glass roofed Smart that doesn't have one?

    Has anybody tried doing this? There's a black track that runs down the middle of the roof which the blind travels on. Do I have to remove the head lining / trim and put this behind, or is there a smart way of doing this? If the trim needs to come down then does it come off easily? Thanks. Might...

    Started by Smartysmartface, 6th April 2019 10:34
    • Replies: 4
    • Views: 685
    23rd April 2019 06:36 Go to last post
  13. MB Star system recommendations?

    I've had a Delphi 150e for a while. It worked (kind of), then packed up. So I bought another one which has yet to arrive. I've been putting off the inevitable since I started with this car - I really need a MB Star setup. I need get as much help as possible with my CANbus prolem (that's another...

    Started by Smartysmartface, 29th August 2018 14:03
    • Replies: 7
    • Views: 1,245
    22nd April 2019 09:37 Go to last post
  14. EML on, caused by SRS/airbag?

    Hi all can the srs/airbag/pretensioner wiring under the seats of an 02 450 put the EML on? Just had mine come on after stuffing satnav under seat! Wots the best obd to use to find out? Thanx.

    Started by jackrussel1996, 14th April 2019 14:34
    • Replies: 7
    • Views: 674
    15th April 2019 18:57 Go to last post
  15. Fuel pump operation

    Testing the pump directly by removing it from the tank resulted with fitting a replacement however the replacement is also suspected of being broken. The replacement is electrified with good positive current and has a buzz when touched but not pumping fuel? What is the operation of the pump?...

    Started by Pocetsize, 12th April 2019 23:14
    fuel pump
    • Replies: 2
    • Views: 519
    13th April 2019 12:37 Go to last post
  16. Glass roof and vinyl strip at front

    My 450 has glass roof which has a black vinyl looking strip from side to side about 6 to 8 inches wide. However this strip has gone crazed and looking shabby. Is this strip easily replaceable, is it a part then can be purchased. ? thanks

    Started by Robinb, 5th April 2019 11:54
    • Replies: 6
    • Views: 646
    12th April 2019 23:03 Go to last post
  17. What holds the battery cover in place in the passenger footwell?

    There is nothing holding my battery cover in place in the passenger footwell. There are two threaded stubs sticking up but I'm keen to find out what is supposed to screw on to them. Smart say they are discontinued. Can anyone post pics of theirs so I can try to see what I am after? My Smart is...

    Started by Bav, 10th April 2019 11:58
    • Replies: 2
    • Views: 546
    10th April 2019 15:12 Go to last post
  18. Tools required for engine rebuild?

    I canít put this off much longer, before I start I wanted to collect the things I need. Weíve all been there, half an hour in and work stops because you need some threaded bar of a certain size or a particular spanner (usually something massive) that you donít have!! Assuming I need new valves...

    Started by Smartysmartface, 30th December 2018 16:12
    3 Pages
    1 2 3
    • Replies: 20
    • Views: 2,380
    24th March 2019 13:11 Go to last post
  19. Disconnect shift paddles?

    Anyone know the way to disconnect the steering shift paddles on fortwo Brabus. got a code saying the are shorting to earth somewhere. Cheers.

    Started by retroman, 19th February 2019 08:11
    2 Pages
    1 2
    • Replies: 10
    • Views: 1,361
    17th March 2019 16:37 Go to last post
  20. 450 intermittent not working

    0.7l 450 2005 model 2 weeks ago went to use car and it would not drive. (started ok) Looked at ODB info and it had clutch actuator error. Reset everything. Test car later and would not engage gear and stalling if put into drive. Then had 3 lines coming up on dash.

    Started by Robinb, 26th February 2019 12:17
    • Replies: 5
    • Views: 845
    1st March 2019 14:13 Go to last post

+ Post New Thread
Page 1 of 21 1 2 3 4 5 11 ... LastLast

Thread Display Options

Use this control to limit the display of threads to those newer than the specified time frame.

Allows you to choose the data by which the thread list will be sorted.

Order threads in...

Note: when sorting by date, 'descending order' will show the newest results first.

Icon Legend

Contains unread posts
Contains unread posts
Contains no unread posts
Contains no unread posts
More than 15 replies or 150 views
Hot thread with unread posts
More than 15 replies or 150 views
Hot thread with no unread posts
Closed Thread
Thread is closed
Thread Contains a Message Written By You
You have posted in this thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts